Recent content by Gunfreak25

  1. Gunfreak25

    Outside air intake?

    Did blocking off the red outline circled above in the factory heater box yield blocked fresh air? Holy thread resurrection batman
  2. Gunfreak25

    85 M1009 runs great, then wont restart

    Your tank sock is likely plugged with crap. I chased an intermittent dying issue with mine for a long time. It would come and go, mostly only an issue when I was offroading since it would stir the sediment in the tank up. Dead pedal, is a lack of fuel flow. As restriction increases it retards...
  3. Gunfreak25

    Need a lesson on engine tempatures and cooling system.

    Have you checked the fan clutch? It should have resistance when spun by hand, engine off of course. Sent from my SM-G955U using Tapatalk
  4. Gunfreak25

    Pulling engine and transmission to insulate firewall?

    There is also a firewall padding available for these trucks on the interior. Google k5 blazer firewall pad. It's around 80 dollars. Just slit the holes in the padding to fit around misc wires and speedo cable. No need to remove everything under there. Sent from my SM-G955U using Tapatalk
  5. Gunfreak25

    Pulling engine and transmission to insulate firewall?

    The big fuse box has a small 10mm I think captured screw you unscrew from the inside. The fuse block then pulls away from the exterior. I would disconnect the lines at the hydro booster. The M923 series trucks use a reflective heat shielding material so the stuff is available. I dont know if...
  6. Gunfreak25

    Pulling engine and transmission to insulate firewall?

    Yes, quite easily if you've taken off the whole front clip. I think it would be time well spent. Sent from my SM-G955U using Tapatalk
  7. Gunfreak25

    York 210 on board air mount, pics

    The air line to tank runs through the firewall, under interior carpet to the very back of the spare tire where the tank is mounted. It's cool when I flip the compressor on I can hear the tank filling. Sent from my SM-G955U using Tapatalk
  8. Gunfreak25

    York 210 on board air mount, pics

    Cool! I will post up the diagram of my bracket if I remember today. All I can tell you guys is it's been the MOST useful addition to any vehicle I've ever made. I am a groundskeeper and use it occasionally at work, offroad, when my sons mother was having tire issues, running an impact to repair...
  9. Gunfreak25

    Cab roof insulation

    I've seen a guy spray expanding foam I'm his roof to fill the void. I'd worry about rust though. However many modern vehicles use foam in the pillars and between panels to dampen noise. For the fiberglass hard top I was going to line with a dynamat type material then fashion a headliner from...
  10. Gunfreak25

    M1009 weather stripping sites

    Thanks Breacher. I spent an hour this morning going through the catalog pages on the link you provided. They carry the upper door foam seals (called "auxiliary" seals) themselves as well. I put an entire shopping cart together that contained every piece of rubber that's replaceable and the...
  11. Gunfreak25

    M1009 weather stripping sites

    In this link you posted : http://www.truckandcarshop.com/trucks73_91/t73_061.html They list part # 81-357912 as Division Bar Channel Upper and Rear (in middle of ad) I can't figure out what exactly that is and where it goes on the door. The $69 kit you mentioned seems like it includes...
  12. Gunfreak25

    Drop tank for rear bumper brackets? (M1009)

    Nope I dont believe so. I just put a new tank in mine. Sent from my SM-G955U using Tapatalk
  13. Gunfreak25

    York 210 on board air mount, pics

    It's been working GREAT! 28 seconds to fill the tires from 15 to 35 psi. I'm still waiting on the air filter and crank case vent but for now its operational. I put a 12v switched fuse panel on the fender. It is fed via a relay controlled by the injection pump 12v solenoid wire. It has 10 fused...
  14. Gunfreak25

    Spectra 31 gallon tank install with part #'s

    They do make plastic k5 tanks. Company called Raybuck comes to mind. Sent from my SM-G955U using Tapatalk
  15. Gunfreak25

    Spectra 31 gallon tank install with part #'s

    Yes sir, M1009. Sent from my SM-G955U using Tapatalk
Top
AdBlock Detected

We get it, advertisements are annoying!

Sure, ad-blocking software does a great job at blocking ads, but it also blocks useful features of our website like our supporting vendors. Their ads help keep Steel Soldiers going. Please consider disabling your ad blockers for the site. Thanks!

I've Disabled AdBlock
No Thanks