Search results

1. I used power steering fluid. I bled it by filling and jacking the vehicle and working the wheel lock to lock a bunch of times. I bought a re-man pump and will install that and hope. 2. I don't see any leaks, so where should I look?

First, Whine and funky steering: Swapped the steering pump for a used one on hand. Swapped the belts. Cleaned up the brackets to the pump and alt. Fixed a broken bolt I found. I have a whine like tires on the highway, faster and slower w/ the engine, ? bearing noise. Steering is "jumpy"...

Hi-lift farmers jack. Spare fluids. Cheapo socket set. Multi-screwdrive, Test meter, WD-40 and some rags (as much for after repair hand cleaning as anything), Tire repair kit (plugs etc), cheapo compressor, Link type fan belt to fit any length, silicone "miracle" tape, Test lead w/ alligator...

My engine has always been loud, louder than my 1009s was. It quiets down accelerating and decelerating when at partial throttle. Otherwise it has awful diesel clatter. Is there a cure? I'm running 15-40 diesel oil and adding 2-stroke to the fuel. I've insulated everything. Pretty sure...

Found a third spare engine w/ a 700r4 attached to this one, very pleased. Replaced the power steering pump w/ a used one. Bought a steering pulley puller and installer. Put the brace on the starter. Changed to the summer weight oil, much quieter. Made a relay, circuit breaker center in a...

Could you fab a pair of rear lights in there? I know their wider, but...

I would replace the modulator, blow out the line vacuum line and check the vacuum at the pump.

Sounds like you have a short to ground somewhere. Trace each wire. Double check your connections. Are you feeding 12v and 24v correctly??? Trying to feed to much current through the wires is what causes this. Either you lack resistance, ie, grounded out, or you have it connected to much of...

I did this same. It fit fine. You need to insulate around it to make a tight fit to force the air through it, and not around it. Mine worked much better after insulating it.

I am looking for Goodyear blue radiator hoses for the m1008, and power steering hoses, plus oil cooler lines. I may get the steering and cooler lines made, but need the radiator hose numbers. I also need a power steering pump. Anything special about the cucv pumps?

New vent window rubbers. Couldn't get the windows out, so split the rubbers to go around the pivot post. Hope it works ok.

My return line came off on the ride to work last night. Reconnected it this AM and filled the steering pump with what I had, ATF. Of course I spilled a bunch on the belts too. Now I have a whine noise like running mud tires on the road. My brakes and asteering are choppy now also. What have...

Good to know. I was hoping for a permanent bulb solution. Got my new sockets in the mail, but am still trying to make the daughters 99 Cherokee pass inspection. Stupid computers and o2 sensors suck.

How much of an amp draw does the 12v feed draw at max? IE. How much is the most current going through the wire from the front battery to the 12v connector with the glow plugs running on the same circuit? Also, if a component has a separate ground, ie. a ground wire and no ground through its'...

I had 10 and 30, but had lost 20. I also have copies of the wiring diagrams but did not see the stuff I needed. Just finally got to a point where I can address this next issue, after I button up the daughters Cherokee.

That explains it, I don't have that one downloaded.

Bump. Does any know the TM diagram locations?

Anyone had any luck plugging LED bulbs into the factory light sockets

Yes, Though I have not finished re-installing the dash yet, or put the fuse box back in place. I did just order all new sockets for each corner that had not yet been replaced.

Got it... Bad connections at sockets, bad grounds, bad connections at the bulkhead and maybe at the inside column connections. All added up to the flashers not working. On the plus side. all my wiring is very clean and has nice soldered connections, shrink wrapped, and fresh tape around the...